平安操作是小型混凝土搅拌车完成其工作任务的基本保证，也是小型混凝土搅拌车操作、维修和周围施工人员人身平安的可靠保证。下面来讲讲内容。
Safe operation is the basic guarantee for small concrete mixers to complete their work tasks, and it is also a reliable guarantee for the operation and maintenance of small concrete mixers and the personal safety of surrounding construction personnel. Now let's talk about the content.
1、检查
1. Check
车身是否堆放杂物，着重检查柴油、机油、各种齿轮油、各种助力油、发动机冷凝液和制动液，的液位和渗漏情况。
Check whether there are sundries stacked on the vehicle body. Focus on checking the liquid level and leakage of diesel, engine oil, various gear oils, various booster oils, engine condensate and brake fluid.
2、运输
2. Transportation
在运输途中，小型混凝土搅拌车应保持3-6转、分的慢速运转。在正常搅拌行驶时，高时速不得超过50km/h。在转弯时不要太急，同时转弯速度不大于15km/h，否则会有翻车危险。
During the transportation, the small concrete mixer shall operate at a slow speed of 3-6 rpm. During normal mixing driving, the high speed shall not exceed 50km/h. Don't turn too fast, and the turning speed is not more than 15km/h, otherwise there will be a danger of rollover.
空车时速不得超过60km/h。当塌落度损失过大时，可在符合混凝土设计配合比例要求的条件下适量加水，此项工作须由试验室技术人员完成。除此之外，严禁往搅拌罐内加水。
The empty speed shall not exceed 60km/h. When the slump loss is too large, the appropriate amount of water can be added under the condition of meeting the requirements of the design mix proportion of concrete. This work must be completed by the laboratory technicians. In addition, it is strictly prohibited to add water to the mixing tank.
3、卸料
3. Unloading
混凝土运送到现场后，由工地负责人依次进行卸料，卸料要干净，避免浪费，要及时清洗小型混凝土搅拌车罐内，排尽积水。
After the concrete is transported to the site, the person in charge of the construction site shall unload the concrete in turn. The unloading shall be clean to avoid waste. The tank of small concrete mixer shall be cleaned in time to drain the accumulated water.
驾驶员应对小型混凝土搅拌车经常进行保养，以保证搅拌罐车的使用寿命，以及正常工作。每周应该给托轮油咀加注一次高压油脂，每班给托轮轨道加一点含石墨或硫化钼润滑脂。每周润滑一次油泵传动轴
The driver shall maintain the small concrete mixer frequently to ensure the service life and normal operation of the mixing tank truck. The supporting wheel oil nozzle shall be filled with high-pressure grease once a week, and the supporting wheel track shall be filled with a little graphite or molybdenum sulfide grease every shift. Lubricate the oil pump drive shaft once a week
小型混凝土搅拌车的平安操作注意事项就从三点来分析讲解了，您对此有什么认识就来我们网站http://www.zkzdsljbc.com进行咨询吧！
Precautions for safe operation of small concrete mixer are analyzed and explained from three points. Please come to our website for your understanding http://www.zkzdsljbc.com Consult!
