全自动混凝土搅拌车是运输混凝土的专用车辆，也就是我们常常在街上看见的边走边转的搅拌车，混凝土运输中通过搅拌筒的缓慢旋转，可有效地防止混土初凝及离析，从而保证混凝土的输送质量。那么搅拌车有哪些使用攻略，能帮助我们更好地使用和保养呢？
The fully automatic concrete mixer truck is a specialized vehicle for transporting concrete, which is a type of mixer truck that we often see walking and rotating on the street. During concrete transportation, the slow rotation of the mixing drum can effectively prevent the initial setting and segregation of concrete, thereby ensuring the quality of concrete transportation. So what are the usage guidelines for mixing trucks that can help us better use and maintain them?
1、搅拌车液压传动系统液压油的压力、油量、油质、油温应达到规定要求，无渗漏现象。
1. The pressure, oil quantity, oil quality, and oil temperature of the hydraulic transmission system of the mixer truck should meet the specified requirements without any leakage.
2、搅拌运输中，装载混凝土量不能超过允许装载质量。
2. During mixing transportation, the amount of concrete loaded cannot exceed the allowable loading mass.
3、搅拌车在露天停放时，装料前应先将搅拌筒反转，使筒内的积水和杂物排出。装料前，好先向筒内加少量水，使进料流畅，防止粘料。
3. When the mixing truck is parked in the open air, the mixing drum should be reversed before loading, so that the accumulated water and debris inside the drum can be discharged. Before loading, add a small amount of water to the cylinder to ensure smooth feeding and prevent sticking.
4、搅拌车行驶中，接长的卸料槽必须翻转后固定在卸槽上，再转与车身垂直部位，用销轴与机架固定，防止由于不固定而引起摆动打伤行人或影响车辆运行。
4. During the operation of the mixer truck, the extended discharge chute must be overturned and fixed on the discharge chute, then turned to a position perpendicular to the vehicle body, and fixed with a pin shaft and frame to prevent swinging and injuring pedestrians or affecting vehicle operation due to lack of fixation.
5、搅拌车通过桥、洞、库等设施时，应注意通过高度及宽度，以免发生碰撞事故。特别需要注意的是现在的四轴罐车的长度很长，在通过桥洞高度接近极限时，长长的车身是下圆弧路面上的一道弦，能通过的高度会减低。
5. When the mixing truck passes through facilities such as bridges, tunnels, and warehouses, attention should be paid to the height and width to avoid collision accidents. It is particularly important to note that the length of current four axle tank cars is very long. When the height of passing through bridge openings approaches the limit, the long body is a chord on the lower curved road surface, and the height that can pass through will be reduced.
6、搅拌装置连续运转时间不超过8h。
6. The continuous operation time of the mixing device shall not exceed 8 hours.
7、搅拌车运送混凝土的时间不得超过搅拌站规定的时间，以免影响混凝土质量。
7. The time for transporting concrete by the mixer truck shall not exceed the time specified by the mixing station to avoid affecting the quality of concrete.
8、运送混凝土途中，搅拌筒不得停转、以防混凝土产生初凝乃离析现象。
8. During the transportation of concrete, the mixing drum must not stop rotating to prevent the initial setting or segregation of the concrete.
9、搅拌筒由正转变为反转时，必须先将操纵手柄放中间位置，待搅拌筒停转后，再将操纵手柄放反转位置。
9. When the mixing drum changes from positive to reverse, the control handle must be placed in the middle position first. After the mixing drum stops rotating, the control handle must be placed in the reverse position.
10、水箱的水量要经常保持装满，以防急用。冬季停车时，要将水箱和供水系统的水放干净。
10. The water tank should always be kept full to prevent emergency use. When parking in winter, the water tank and water supply system should be drained clean.
在保证混凝土质量的同时，搅拌车的驾驶和保养护理也同样值得重视，那么搅拌车的使用攻略您要多关注，更多事项的了解就来我们网站http://www.zkzdsljbc.com做咨询！
While ensuring the quality of concrete, the safe driving and maintenance of mixer trucks are also worth paying attention to. Therefore, you should pay more attention to the usage guidelines of mixer trucks. For more information, please visit our website http://www.zkzdsljbc.com Consulting!
