搅拌车在使用时要注意如果设备没有润滑油，设备不允许运转，而且要正确安装，确保以及长期稳定运行；另外日常维护中，应检查设备部件是否损坏等；下面就详细介绍相关内容。
When using the mixer truck, it should be noted that if the equipment does not have lubricating oil, the equipment is not allowed to operate, and it should be installed correctly to ensure safe and long-term stable operation; In addition, during daily maintenance, check whether the equipment components are damaged, etc; The relevant contents are described in detail below.
小型混凝土搅拌车使用注意事项：
Precautions for safe use of small concrete mixer:
1、搅拌车需要正确安装和使用，以确保和长期稳定运行。
1. The mixer truck needs to be installed and used correctly to ensure safe and long-term stable operation.
2、安装人员应具备相应的资质和熟悉机械设备安装知识的人员进行安装工作。
2. The installation personnel shall be qualified and familiar with the installation knowledge of mechanical equipment.
3、搅拌器应垂直安装，垂直度偏差不超过5度。
3. The agitator shall be installed vertically, and the verticality deviation shall not exceed 5 degrees.
4、禁止在配料搅拌系统中搅拌高粘度的固体和液体。
4. It is forbidden to mix solids and liquids with high viscosity in the batching and mixing system.
5、电机和轴承的温度不能超过75℃。
5. The temperature of motor and bearing shall not exceed 75 ℃.
6、没有润滑油，电机、轴承和变速箱不能运转。
6. Without lubricating oil, the motor, bearing and gearbox cannot operate.
7、搅拌器轴和叶片不能在弯曲或变形的情况下运行。如果轴弯曲或刀片变形，请立即停机进行处理或更换。
7. The agitator shaft and blades cannot operate under bending or deformation. If the shaft is bent or the blade is deformed, stop the machine immediately for treatment or replacement.
8、搅拌系统运行过程中，严禁杂物进入反应池，以免损坏搅拌轴和叶片。
8. During the operation of the mixing system, sundries are strictly prohibited from entering the reaction tank to avoid damaging the mixing shaft and blades.
9、如果人们需要进入反应罐进行清洁或维护，必须切断电机电源，并悬挂“禁止关闭”的警告标志。在手动清洗和维护反应罐时，必须有专人在反应罐外进行监督。
9. If people need to enter the reaction tank for cleaning or maintenance, they must cut off the power supply of the motor and hang a warning sign of "no shutdown". When manually cleaning and maintaining the reaction tank, special personnel must be assigned to supervise outside the reaction tank.
10、搅拌系统运行一段时间后，如果反应罐底部有沉淀物、杂质和杂物，应及时停止，用清水冲洗或人工清理，以确保搅拌器的运行。
10. After the mixing system operates for a period of time, if there is sediment, impurities and sundries at the bottom of the reaction tank, it should be stopped in time, washed with clean water or manually cleaned to ensure the safe operation of the mixer.
小型混凝土搅拌车的日常维护
Daily maintenance of small concrete mixer
1、检查油泵需要需要进行注入油脂，而且需要检查空气压缩机曲轴箱中的润滑油质量如何是否需要进行更换。
1. Check whether the oil pump needs to be filled with grease and whether the lubricating oil in the crankcase of the air compressor needs to be replaced.
2、润滑点一定要进行润滑，设备的卸料门轴，每个储料斗和称重桶门轴，胶带输送机等地方都是需要进行润滑的。
2. The lubrication points must be lubricated. The unloading gate shaft of the equipment, the gate shaft of each storage hopper and weighing bucket, and the belt conveyor all need lubrication.
3、还需要检查刀片还有搅拌臂等磨损情况，如果磨损的比较严重需要进行修补或者进行进行更换。将搅拌器的振动器连接螺栓拧紧。
3. It is also necessary to check the wear of blades and mixing arms. If the wear is serious, it needs to be repaired or replaced. Tighten the connecting bolts of the vibrator of the mixer.
6、检查设备里面的接触器，还有中间继电器的静态继电器有没有损坏。
6. Check whether the contactor in the equipment and the static relay of the intermediate relay are damaged.
7、设备每次运行结束之后，都需要清理干净设备以备下次继续使用。
7. After each operation, the equipment needs to be cleaned for further use.
8、在冬天比较寒冷的季节，设备里面不要残留多余的水，在使用结束之后要排出干净。
8. In cold winter, do not leave excess water in the equipment, and drain it after use.
以上就是今天为大家介绍的关于问题以及注意事项的全部内容，希望对大家能有所帮助，想要了解更多内容可以电话联系我们或者关注我们的网站http://www.zkzdsljbc.com，我们的工作人员会及时与您取得联系。
The above is all about the problems and precautions introduced to you today. I hope it can help you. If you want to know more, you can contact us by phone or follow our website http://www.zkzdsljbc.com , our staff will contact you in time.
