根据混凝土搅拌车使用状况，结合参考设备累计台时，安排对混凝土搅拌车进行检修，检测、保养、维修、防腐工作。使混凝土搅拌车通过管理达到费用低、寿命长、效能高的效果，并满足混凝土运输要求。对混凝土搅拌车维护保养，在下面几个方面要达到以下标准：
According to the service conditions of the concrete mixer and the accumulated machine hours of the reference equipment, arrange the maintenance, inspection, maintenance, repair and anti-corrosion of the concrete mixer. Through management, the concrete mixer truck can achieve the effect of low cost, long service life and high efficiency, and meet the requirements of concrete transportation. For the maintenance of concrete mixer truck, the following standards shall be met:
1.供水系统：供水系统水泵及部件齐全完整，无泄漏。
1. Water supply system: the water pump and components of the water supply system are complete without leakage.
2.发动机：运转无异常，油压水温正常，皮带松紧适宜，滤清器清洁有效。
2. Engine: no abnormal operation, normal oil pressure and water temperature, proper belt tightness, and clean and effective filter.
3.制动系统：手脚制动灵敏有效，不跑偏，压印、拖印、踏板行程符合规定。
3. Brake system: the hand and foot brake are sensitive and effective, without deviation, and the stamping, dragging and pedal travel meet the requirements.
4.灯光系统：各种仪表齐全，指示数据准确，指示灯齐全、完好，声光信号及报警系统齐全完整有效。
4. Lighting system: various instruments are complete, indicating data is accurate, indicating lamps are complete and intact, and audible and visual signals and alarm systems are complete, complete and effective.
5.搅拌系统：筒体与托轮接触良好，不跑偏窜动。搅拌筒叶片无严重磨损变形。筒内和出料口无严重积料。
5. Mixing system: the cylinder is in good contact with the supporting wheel, without deviation and movement. The blades of mixing drum shall be free from serious wear and deformation. There is no serious material accumulation in the barrel and at the outlet.
6.润滑系统：和润滑装置齐全、完好，油路畅通，润滑部位润滑充分，润滑油型号、油量油质符合规定要求。
6. Lubrication system: and lubricating devices are complete and intact, the oil path is smooth, the lubricating parts are fully lubricated, and the lubricating oil model, quantity and quality meet the specified requirements.
7.电器系统：全车线路完整，连接卡固定符合要求。电瓶整洁，固定牢靠，电解液面符合要求。
7. Electrical system: the whole vehicle line is complete, and the connection card is fixed as required. The battery shall be clean and firmly fixed, and the electrolytic liquid level shall meet the requirements.
8.转向系统：转向盘自由转向量不大于30度，转向助力装置灵敏有效，转向节及臂、转向横直拉杆无损伤，球销不松旷。
8. Steering system: the free steering volume of the steering wheel shall not be greater than 30 degrees, the power steering device shall be sensitive and effective, the steering knuckle, arm and steering straight rod shall not be damaged, and the ball pin shall not be loose.
9.液压系统：油泵和马达工作正常，压力达到额定值。液压油型号、油量、油质符合规定要求，油温不大于80℃，油管连接良好，无泄漏现象。
9. Hydraulic system: the oil pump and motor work normally and the pressure reaches the rated value. The model, quantity and quality of hydraulic oil shall meet the specified requirements, the oil temperature shall not exceed 80 ℃, and the oil pipe shall be well connected without leakage.
10.整机要求：全车结构无变形、脱焊、开裂现象，螺栓无松动，各总成、零部件及附属装置齐全完整。主要工作性能达到额定指标。全车清洁和无混凝土积料。
10. Complete machine requirements: the whole vehicle structure shall be free of deformation, desoldering and cracking, bolts shall be free of looseness, and all assemblies, parts and accessories shall be complete. The main working performance reaches the rated index. The whole vehicle is clean and free of concrete accumulation.
11.底盘部分：混凝土搅拌车变速箱和分动箱无乱档现象。前后桥传动机构无异响和过热现象。离合器分离，结合平稳，工作可靠。轮胎磨损不超过有关规定，气压符合规定，备胎及工具齐全。
11. Chassis: gearbox and transfer case of concrete mixer shall be free of gear disorder. The front and rear axle transmission mechanism shall be free of abnormal noise and overheating. The clutch is separated, and the combination is stable and reliable. The tire wear shall not exceed the relevant regulations, the air pressure shall comply with the regulations, and the spare tire and tools shall be complete.
混凝土搅拌车维护保养达到怎样的标准？从11个方面来讲解了问题，希望对您有所帮助，您平日使用要做好检查维护工作才行！更多相关信息就来我们网站http://www.zkzdsljbc.com咨询吧！
What standard does the maintenance of concrete mixer reach? I explained the problem from 11 aspects and hope it will be helpful to you. You should do a good job of inspection and maintenance in daily use! Come to our website for more information http://www.zkzdsljbc.com Consult!
