随着社会的飞速发展，大兴建设各种基础设施，施工过程中经常用到混凝土搅拌车。 现有的混凝土搅拌车包括搅拌装置和装有混凝土的搅拌筒。 在混凝土搅拌车的后部，两端开口的灰槽与搅拌筒的一端固定连接。
With the rapid development of society, Daxing has built various infrastructure, and concrete mixer is often used in the construction process. The existing concrete mixer includes a mixing device and a mixing drum equipped with concrete. At the rear of the concrete mixer, the ash tanks with openings at both ends are fixedly connected with one end of the mixing drum.
灰槽断面一般为弧形，灰槽延长线与地面成一定角度，便于混凝土浇筑。 然而，现有灰槽在使用过程中，倾倒过程中往往会附着混凝土，在颠簸运输过程中容易散落，污染环境。
The section of ash chute is generally arc-shaped, and the extension line of ash chute forms a certain angle with the ground to facilitate concrete pouring. However, during the use of the existing ash chute, the concrete is often attached during the dumping process, which is easy to scatter in the bumpy transportation process and pollute the environment.
而且，在将混凝土拉到市区各个工地的过程中，由于路况和司机的操作问题，经常会出现沿途混凝土洒落的情况。 它不仅污染了城市道路环境，而且随着时间的推移会形成顽固的水泥块，难以清理。
Moreover, in the process of pulling the concrete to various construction sites in the urban area, due to the road conditions and the operation problems of drivers, the concrete will often be spilled along the way. It not only pollutes the urban road environment, but also forms stubborn cement blocks over time, which are difficult to clean up.
混凝土搅拌运输车 每辆罐车的后料斗设计有防漏料斗，固定在混凝土搅拌运输车卸料口正下方，下口可开闭。 在车辆颠簸行驶过程中，每当混凝土从卸料口漏出时，这个小盒子就可以接住抛出的混凝土。 如果满了，司机只需打开箱下的开关，将箱内的混凝土卸掉即可。 这样，即使料斗滴下水泥浆，也只会滴入料斗，不会滴落到路面造成污染。 从而了混凝土搅拌车沿途漏水的问题。
The rear hopper of each tank car of the concrete mixer truck is designed with a leak proof hopper, which is fixed directly below the discharge port of the concrete mixer truck, and the lower port can be opened and closed. During the bumpy driving of the vehicle, this small box can catch the thrown concrete whenever the concrete leaks from the discharge port. If it is full, the driver only needs to turn on the switch under the box and unload the concrete in the box. In this way, even if the cement slurry drops from the hopper, it will only drop into the hopper and will not drop to the road to cause pollution. Thus, the problem of water leakage along the way of concrete mixer is solved.
混凝土搅拌车防散装置，现场施工时，灰槽体底板上的插销打开，混凝土可以流出灰槽体； 运输时将底板的固定端和开口端封闭，以保证灰槽体中放入混凝土。 即使混凝土搅拌车在路面颠簸，灰槽体上的保护层也能防止混凝土从车上散落。 在混凝土搅拌车运输过程中，防止混凝土从灰槽中飞散，了环境污染问题。
Anti dispersion device of concrete mixer truck. During on-site construction, the bolt on the bottom plate of the ash tank body is opened, and the concrete can flow out of the ash tank body; During transportation, the fixed end and open end of the bottom plate shall be closed to ensure that the concrete is put into the ash tank. Even if the concrete mixer truck bumps on the road, the protective layer on the ash tank can prevent the concrete from scattering from the truck. During the transportation of concrete mixer truck, the concrete is prevented from flying from the ash tank and the problem of environmental pollution is solved.
混凝土搅拌车滴水、滴水主要是由于混凝土搅拌车满载、运输过程中制动、红绿灯起步、颠簸等原因造成的。 混凝土搅拌车出厂前，可以先用随车自带的自动高压喷淋进行清洗，保证车身不带泥上路。 其次，在搅拌车上安装防漏斗是防止“洒水滴”的好办法，提高驾驶员文明驾驶质量，自觉减少搅拌车滴漏，起到净化路面的作用。
The dripping of concrete mixer truck is mainly caused by the full load of concrete mixer truck, braking during transportation, traffic light starting, bumping and other reasons. Before the concrete mixer truck leaves the factory, it can be cleaned with the automatic high-pressure spray provided with the truck to ensure that the car body does not carry mud on the road. Secondly, installing an anti funnel on the mixer is a good way to prevent "water droplets", improve the civilized driving quality of drivers, consciously reduce the dripping of the mixer and purify the road.
更多相关内容就来网站http://www.zkzdsljbc.com进行咨询吧！
Come to the website for more relevant content http://www.zkzdsljbc.com/ Consult!
