1. When the water pump is working, the mixer is not allowed to run idle, and the continuous use should not exceed 15 minutes.
2、搅拌车放料前先把出料斗溜槽打湿。放料时把车尽量停在平地上放料。
2. Wet the hopper chute before discharging. When discharging, park the car on the flat ground as far as possible.
3、卸料不要大意和放料工打好关系。放料时尽量自己看着，免得放料工乱操作放料操作杆，每次罐子正反转中间位子时尽量停一下，减速机，托轮等。与放料工打好关系，卸料时也不要睡的太熟，万一工人闹情绪，把你车子放到工地不转罐子，造成闷罐麻烦了。
3. Don't be careless in discharging and have a good relationship with the discharger. When discharging, try to watch by yourself, so as to avoid the disorderly operation of the discharging lever by the discharging worker. Every time when the can is in the middle position of forward and reverse rotation, try to stop, reducer, supporting wheel, etc. Have a good relationship with the discharger, and don't sleep too well when discharging. In case the worker is in a bad mood, put your car on the construction site and don't turn the can, which will cause the trouble of stuffy can.
4、搅拌车水箱的水量要经常保持装满，以备急用，冬季停机后，应将水箱、水泵、水管、搅拌筒内的水放净，并停放在朝阳、不积水的地方，以免冻坏机械。
4. The water tank of the mixer should always be kept full for emergency use. After shutdown in winter, the water in the water tank, water pump, water pipe and mixing drum should be drained, and the mixer should be parked in the sunny place without ponding, so as to avoid freezing the machinery.
5、卸料前让搅拌罐全速运转一两分钟。让混凝土充分搅拌，必要时可以加一些水，让混凝土搅拌得更均匀，也方便卸料。
5. Let the mixing tank run at full speed for one or two minutes before discharging. Let the concrete mix fully. If necessary, add some water to make the concrete mix more evenly and discharge easily.
6、搅拌车工作完毕，应把搅拌筒内部和车身清洗干净，不能使剩余的混凝土留在筒内。
6. After the mixing truck is finished, the inside and body of the mixing drum shall be cleaned, and the remaining concrete shall not be left in the drum.
7、 搅拌罐要仔细地冲洗干净。洗罐子时要仔细的冲洗干净，并把水反复的正反转两次，再放出来，然后一趟时把水箱的水放进罐子，再回到站加水彻底清洗罐子。
7. The mixing tank should be washed carefully. Wash the pot carefully, and put the water in the positive and negative direction twice, then put the water in the tank, and then go back to the station to add water to clean the pot thoroughly.
8、搅拌车在冬季应及时安装保温套，并使用防冻液对搅拌车加以，根据天气变化更换燃油标号，机械的正常使用。
8. Mixer in winter should be timely installed insulation, and use antifreeze on the mixer, according to the weather change to change the fuel label, the normal use of machinery.
9、在检查、修理搅拌车液压传动部分时，应使发动机和液压泵在没有压的情况下进行。
9. When checking and repairing the hydraulic transmission part of mixer truck, the engine and hydraulic pump should be operated without pressure.
10、在调整混凝土自动上料搅拌车各部间隙、行程、压时，应由专职员检查同意；更换机件时，由部长或主管经理签字，否则出现问题后追究有关人员责任。
10. When adjusting the clearance, travel and pressure of each part of the automatic concrete feeding mixer, it shall be checked and agreed by the full-time staff; when replacing the parts, it shall be signed by the minister or the manager in charge, otherwise the relevant personnel shall be investigated for responsibility after the problems occur.
有了混凝土搅拌车上面的小总结，希望对广大客户有所帮助，如果有什么不理解的或者寻求帮助的请点击我们的网站：http://www.zkzdsljbc.com或者来电咨询，我们会尽全力为您
With the summary of concrete mixer truck, we hope to help our customers. If there is anything you don't understand or ask for help, please click our website: http://www.zkzdsljbc.com Or call consultation, we will try our best to solve for you
