我们知道，全自动混凝土搅拌车的维护可以概括每日每周每月每年等阶段，这表明了搅拌车维护的重要性。让我们看一下全自动混凝土搅拌车每星期应该检查的项目。
As we know, the maintenance of automatic concrete mixer can be summarized into daily, weekly, monthly and annual stages, which shows the importance of mixer maintenance. Let's take a look at the items that the automatic concrete mixer should check every week.
1、检查钢丝绳磨损情况并在其表明涂少许润滑油，钢丝绳磨损到一定程度后，应进行更换。
1. Check the wear of wire rope and apply a little lubricating oil when it is indicated. After the wire rope is worn to a certain extent, it should be replaced.
2、检查减速箱油面，油泵油量，检查各润滑部位的情况，往料斗滚轮轴承及滑轮轴承加注润滑油。
2. Check the oil level of the gearbox and the oil volume of the oil pump, check the condition of each lubricating part, and add lubricating oil to the hopper roller bearing and pulley bearing.
3、供水装置要保持清洁，以免堵塞，对吸水阀检查清洗一次。
3. The water supply device shall be kept clean to avoid blockage. The suction valve shall be checked and cleaned once.
4、检查行程开关摇臂是否松动，如有松动应予必要调整。
4. Check whether the rocker arm of the travel switch is loose, and adjust it if necessary.
5、检查叶片连接螺栓，支撑臂连接螺栓是否松动酌情调整，叶片与筒壁间的间隙大间隙5mm并作必要的拧紧。
5. Check whether the connecting bolts of the blade and the support arm are loose, and adjust them as appropriate. The gap between the blade and the cylinder wall is 5mm and tighten it as necessary.
6、检查电气箱中接触器触头情况。
6. Check the contact of the contactor in the electrical box.
7、拧开放淤塞，检查轴端密封，作必要的调整修理和更换。
7. Unscrew the silting, check the shaft end seal, and make necessary adjustment, repair and replacement.
全自动混凝土搅拌车定期应该检查的项目：
Items that should be checked regularly for automatic concrete mixer:
1、对卷扬提升制动器进行检查并作适当的调整。
1. Check the winch lifting brake and make proper adjustment.
2、对水泵，节流阀进行检查，是否有漏水现象。
2. Check the water pump and throttle valve for water leakage.
3、对开式齿轮进行检查涂抹润滑油并调整皮带松紧。
3. Check and apply lubricating oil to the open gear and adjust the belt tightness.
4、检查叶片，衬板的磨损情况，并酌情更换。
4. Check the wear of blades and lining plates and replace them as appropriate.
小编提醒广大用户：混凝土搅拌车的安装，应由专门的人员按出厂说明规定进行，并应在技术的主持下组织调试，在各项技术性能指标全部符合规定并经验收合格后，方可使用。更多相关内容就来我们网站http://www.zkzdsljbc.com咨询了解！
The small editor reminds users that the installation of the concrete mixer shall be carried out by special personnel according to the factory instructions, and the commissioning shall be organized under the auspices of the technology. The concrete mixer can be used only after all the technical performance indicators meet the requirements and pass the acceptance. More relevant content will come to our website http://www.zkzdsljbc.com Ask about it!
