混凝土搅拌车对预拌混凝土的输送时间要求是怎样的呢？下面小编为您讲解一番。
What is the delivery time requirement of concrete mixer for ready mixed concrete? The following editor will explain it to you.
任何预拌混凝土在未添加缓凝剂的情况下，都在1小时左右进入初凝状态，这时再进行混凝土浇注施工将影响混凝土的工程质量。因此搅拌车运送预拌混凝土有其时间控制的输送半径要求。一般控制在1小时以内。
Any ready mixed concrete will enter the initial setting state in about 1 hour without adding retarder. At this time, the concrete pouring will affect the quality of the concrete. Therefore, the transportation of ready mixed concrete by mixer truck has its time controlled transportation radius requirements. Generally controlled within 1 hour.
从商用预拌混凝土进料到卸料完毕的长时间为90分钟，且搅拌筒总转数不大于300转。如嫌原有的卸料槽不够长，需另外接长时，请用支柱将接长部分撑住。
The long time from the feeding of commercial ready mixed concrete to the completion of unloading is 90 minutes, and the total number of revolutions of the mixing drum is not more than 300. If the original discharge chute is not long enough and needs to be lengthened, please support the lengthened part with a pillar.
混凝土出料完毕后，应迅速对搅拌筒内部进行冲洗。注意：如不及时冲洗，不仅会造成搅拌筒内混凝土的粘结，使装载量减少，进料不畅，还会给机构带来故障，是事故的诱发因素之一。务必注意!
After the concrete is discharged, the inside of the mixing drum shall be washed quickly. Note: if not washed in time, it will not only cause the concrete in the mixing drum to bond, reduce the loading capacity, and obstruct the feeding, but also bring failure to the mechanism, which is one of the inducing factors of the accident. Be careful!
空车行驶时，搅拌筒应以与装载有料时行驶同样的搅动的转速回转。
When the truck is running empty, the mixing drum shall rotate at the same stirring speed as when the truck is loaded.
满载的混凝土正在是正转的时候若是需要反转，那么就需要操控手柄使其能够正传挺稳之后，在操控手柄让其反转。不可再进行正转的时候操控手柄让其反转。
If the full load concrete needs to be reversed when it is rotating forward, it needs to control the handle to make it forward and stable, and then reverse it. When the forward rotation is no longer possible, control the handle to reverse it.
混凝土搅拌车的工作装置的连续时间不能够有超过了八小时。
The continuous time of the working device of the concrete mixer shall not exceed eight hours.
车辆处于空载的驾驶过程中，搅拌筒不能够停转，以免在行驶的过程中在颠簸的时候所造成了拖轮以及滚道的磕碰使其出现了异常的损坏。
When the vehicle is in the no-load driving process, the mixing drum cannot stop running, so as to avoid the collision of the tug and the raceway caused by the bumping during the driving process and the abnormal damage.
混凝土搅拌车在进行输送着混凝土的容量、质量、以及其塌落度都须是要符合着其混凝土行业的要求以及标准的。
The capacity, quality and slump of concrete transported by the concrete mixer must meet the requirements and standards of the concrete industry.
注意：搅拌车行驶时，如搅拌停止回转，则搅拌筒滚道与搅拌筒托轮上会产生压痕，并会发生异常噪声。因此，务请注意。更多相关事项就来我们网站http://www.zkzdsljbc.com咨询吧。
Note: when the mixer truck is running, if the mixing stops rotating, there will be indentation on the mixing drum raceway and the mixing drum supporting wheel, and abnormal noise will occur. Therefore, please be careful. For more information, please visit our website http://www.zkzdsljbc.com Consult.
